Calculating A Tachometer Signal From Onboard A Smart Vibration Sensor
Because of the bandwidth limitation of the engine controller, all helicopter gearboxes change speed over time. This change in speed necessitates the resampling of the data, based on a tachometer signal, to facilitate shaft, gear and bearing analysis of the rotating equipment. Without resampling, the quality of vibration analysis is degraded, and many mechanical faults would be missed. Further, interfacing with existing tachometer can be both expensive, and in some cases change certification requirements. The ability for a smart sensor to acquire vibration data, extract the shaft speed from the vibration data, and then process the data allows vibration based fault detection capability at a lower cost, weight and reduced installation complexity than previously possible. Reducing cost, weight and installation complexity will expand the business case for condition monitoring, improving safety and reliability in industrial and transportation systems. This paper demonstrates a twostep process to recover a tachometer signal from vibration data that is of higher quality than raw tachometer data. Statistics are generated from known fault cases to demonstrate the effectiveness.
How to Cite
Tachometer signal, Smart sensor, Vibration
This work is licensed under a Creative Commons Attribution 3.0 Unported License.
The Prognostic and Health Management Society advocates open-access to scientific data and uses a Creative Commons license for publishing and distributing any papers. A Creative Commons license does not relinquish the author’s copyright; rather it allows them to share some of their rights with any member of the public under certain conditions whilst enjoying full legal protection. By submitting an article to the International Conference of the Prognostics and Health Management Society, the authors agree to be bound by the associated terms and conditions including the following:
As the author, you retain the copyright to your Work. By submitting your Work, you are granting anybody the right to copy, distribute and transmit your Work and to adapt your Work with proper attribution under the terms of the Creative Commons Attribution 3.0 United States license. You assign rights to the Prognostics and Health Management Society to publish and disseminate your Work through electronic and print media if it is accepted for publication. A license note citing the Creative Commons Attribution 3.0 United States License as shown below needs to be placed in the footnote on the first page of the article.
First Author et al. This is an open-access article distributed under the terms of the Creative Commons Attribution 3.0 United States License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original author and source are credited.