It has been shown that Acoustic Emission (AE) can be used to classify different friction states and identify defects in journal bearings. In addition, it has been demonstrated in experimental setups that AE can be used to estimate the wear volume of sliding lubricated metallic contacts. The aim of our work is to monitor the wear during the operation of a journal bearing. This work deals with the development of a prognosis system for a detection of the wear and its volume by means of AE before an actual fault occurs. For this purpose, a journal bearing test bench was developed, where the oil temperature for the lubrication, load and rotational speed can be set. Experiments were carried out under different operating conditions and lasted up to 20 hours each. To establish a correlation between wear and AE, the wear volume is determined by comparing recorded roundness profiles of the inner race before and after each experiment at multiple positions. The method used is validated by measuring the roughness of the inner race surface, thus confirming the position of the wear. The analysis of the recorded AE signals shows an amplitude modulation as well as bursts. The frequency of the amplitude modulation correlates with the rotational speed even at higher velocities. Bursts in the AE signal are directly related to wear. Various features, e.g. root mean square value and properties of the measured bursts, of the AE signal and their relevance for the prediction of the wear are analyzed. A quantitative estimation of the volume proves to be challenging, while a qualitative estimation of occurrence and severity of wear can be reliably detected.
How to Cite
acoustic emission, classification, journal bearing, wear, random forest classifier
The Prognostic and Health Management Society advocates open-access to scientific data and uses a Creative Commons license for publishing and distributing any papers. A Creative Commons license does not relinquish the author’s copyright; rather it allows them to share some of their rights with any member of the public under certain conditions whilst enjoying full legal protection. By submitting an article to the International Conference of the Prognostics and Health Management Society, the authors agree to be bound by the associated terms and conditions including the following:
As the author, you retain the copyright to your Work. By submitting your Work, you are granting anybody the right to copy, distribute and transmit your Work and to adapt your Work with proper attribution under the terms of the Creative Commons Attribution 3.0 United States license. You assign rights to the Prognostics and Health Management Society to publish and disseminate your Work through electronic and print media if it is accepted for publication. A license note citing the Creative Commons Attribution 3.0 United States License as shown below needs to be placed in the footnote on the first page of the article.
First Author et al. This is an open-access article distributed under the terms of the Creative Commons Attribution 3.0 United States License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original author and source are credited.